Greening Brooklyn One Garden at a Time

A discussion of how we can increase the security our local food supply at a time when rising fuel costs, climate change and political turmoil make it particularly vulnerable. As seen through the lens of the Imani Gardens, located at 1680 Pacific Street and 87-91 Schenectady Street.

  • Home
    Home This is where you can find all the blog posts throughout the site.
  • Categories
    Categories Displays a list of categories from this blog.
  • Tags
    Tags Displays a list of tags that have been used in the blog.
  • Bloggers
    Bloggers Search for your favorite blogger from this site.
  • Team Blogs
    Team Blogs Find your favorite team blogs here.
  • Login

Climate Battery Completed At Imani II

Posted by on in Imani
  • Font size: Larger Smaller
  • Hits: 3174
  • Subscribe to this entry

As the darkness of December descends on Imani, a group of volunteers completed work on the climate battery in the greenhouse at Imani II.  Just to recapitulate, the climate  battery concept was introduced by Jerome Osentowsky at the Central Rocky Mountain Permaculture Institute to extend the growing season in their greenhouses.  Located in Basalt Colorado, CRMRI has been able to achieve remarkably warm temperatures in their greenhouses during cold winter weather using what Jerome calls a "climate battery".  At 7,200 feet above sea level, the greenhouses suffer very low winter temperatures, but also enjoy lots of sunlight.  CRMPI was able to capture the heat generated by the sun and keep it in the greenhouses using a climate battery. The climate battery consists of ducts located at the top of the greenhouse which connect to similar ducts in the ground under the greenhouse.  Using small fans, the heat available during the hot sunny days is blown into the ground where it warms the soil.  Jerome grows a number subtropical and tropical plants in the greenhouses.  When the cold is too intense for even the climate battery to overcome, the staff fires up the adjacent hot tub and lets the heat warm the greenhouse.  Now that's not just sustainable, that's a great permaculture lifestyle!

At Imani II. we've run 4" aluminium duct commonly used to exhaust household dryers along the top of the greenhouse.  We've connected this to 4" drainage pipe buried a few inches below the ground on each side of the greenhouse floor.  At the front of the upper duct is a 12 volt fan repurposed from a discarded computer.  The fan is controlled by a thermostat commonly used for attic fans.  When the temperature at the top of the greenhouse reaches 60 degrees, the fan comes on and blows hot air into the buried drainage pipes.  

To enhance the solar gain, we've placed six donated 55 gallon plastic drums filled with water along the sides of the greenhouse.  The water will capture the heat during the days and use it to warm the greenhouse at night.  We're also using the tops of the drums as platforms for our planting beds.

The fan is powered by two 6 volt deep-cycle batteries connected in series to create 12 volts.  The batteries are charged by a single 100 watt PV panel mounted on the south side of the greenhouse.

We installed an inexpensive ($12) electronic indoor/outdoor thermometer to measure the indoor and outdoor.  Because it has been raining here in Brooklyn for the past week, the differential has only been averaging a couple of degrees between indoor and outdoor.  I'm waiting on some sunny weather to see how much the sun raises the indoor temperature.

Today, Roman Yavich, Corey Hopp, Tommy and myself spread about 700 pounds of sand and gravel on the floor of the greenhouse on top of a layer of heavy plastic.  The plastic will prevent moisture from coming up into the greenhouse house and the sand and gravel will help retain heat.  

Finally we painted the drums black to increase their heat absorption.  

Total cost: $172.  The solar panel and batteries are not included as they were borrowed from our aquaponics system which doesn't work in the winter.

Below is the story in pictures.

b2ap3_thumbnail_Imani-greenhouse-with-solar-panel-11-10-14.jpg

A solar panel affixed to the south side of the greenhouse charges two deep-cycle storage batteries

 

b2ap3_thumbnail_015.JPG

An aluminum duct that runs along the top of the greenhouse ceilig is tied into buried drainage pipe.

 

b2ap3_thumbnail_014.JPG

Plastic drainage pipe is buried in the floor to transfer the heat at the top into the soil.

b2ap3_thumbnail_002.JPG

Sand is placed top of plastic on the floor of the greenhouse.

b2ap3_thumbnail_004.JPG

 

Tommy and Cory spreading gravel on top of the sand  

b2ap3_thumbnail_006.JPG

 

Roman painting the water-filled drums with black paint

b2ap3_thumbnail_008.JPG

 

Some trays of micro greens on top of the black drums.

 

We will be monitoring the climate battery's performance over the winter months and will fine tune and adjust the system based on its performance.  As an old boss once told me, "all good big systems are based on good small ones".  As we learn about climate batteries in our little 10' x 12' greenhouse, we hope to apply our experience to larger greenhouses.  The goal: help feed ourselves year round, not just in the warm summer months.  After all, I do eat 12 months a year, and I suppose you do the same.  Let's learn how grow locally 12 months a year as well.

 

 

 

 

0

Comments

GPP Login

Calendar

Loading ...